Dongfeng DFL3251A dump truck. Guide

Dongfeng DFL3251A dump truck. Guide - part 1

Important information

In the following cases, will not be held responsible for reliability, safety and serviceability

car:

The vehicle identification plate has been replaced and does not match the vehicle registration plate or chassis issued by our company.

The requirements of this Vehicle Operation Manual have been violated.

The frequency of vehicle maintenance work (including maintenance during the initial period of operation) established by this Operation Manual was violated; maintenance was carried out

on service

stations not authorized by the manufacturer (seller). The fuels and lubricants used in operation, special fluids, filters, drive belts, and electrical fuses do not comply with those recommended in this Manual. If a vehicle malfunction occurs during the warranty period, the consumer independently repaired it without contacting a service center or service station authorized by the Commercial Vehicle Company and.

The consumer, without the prior official approval of the manufacturer, made changes to the original design of the car, produced it

re-equipment, replaced any

components or parts (for example, increased the volume of the body, strengthened the car frame; installed spring sheets of greater thickness than the original ones; increased the number of sheets; used tires that differed in size, load or ply rate from the recommended ones, etc.), which led to to vehicle failure.

When repairing (maintenance) a car, the consumer used parts (consumables) that were not included in those recommended by the manufacturer, which led to the car’s failure.

If a malfunction occurred, the consumer did not take measures to immediately eliminate it, but continued to operate the faulty vehicle, which led to its failure.

When a car was involved in a traffic accident, the consumer did not contact the traffic police and the insurance company to determine the degree of liability in the incident.

During operation, the consumer overloaded the car, violated the recommended speed limits and other recommendations given in this Manual.

Some external unfavorable factors, and not defects of the car, caused its collision, fire, scratches, etc.

10.

Damage and (or) failure of the vehicle occurred under the influence of force majeure circumstances, for example, such as flood, lightning strike, storm, hail, etc.

11.

The failure of the vehicle or the occurrence of a malfunction occurred as a result of natural aging or due to normal wear and tear of the components and assemblies of the vehicle.

12.

Damage and (or) failure of the vehicle occurred due to the consumer’s refusal to inspect and diagnose vehicle malfunctions by representatives of the service station.

13.

The warranty period for the vehicle has expired.

14.

The defects did not arise due to the use of low-quality materials during the manufacturing process or the vehicle’s design not meeting the characteristics given in this Manual, but due to some other reasons not related to manufacturing defects.

Reproduction and reproduction of this Manual in whole or in part is prohibited.

without written permission from the company.

CATALOG OF SPARE PARTS FOR DONGFENG ENGINES DONG FENG

ADAPTER FLANGE ADAPTER DONGFENG DONG FENG ACTUATOR FUEL DISPENSER PUMP DONGFENG DONG FENG BENDIX STARTER DONGFENG DONG FENG ENGINE CONTROL MODULE ECU ECM DONGFENG DONG FENG CYLINDER BLOCK DONGFENG DONG FENG DONGFENG CYLINDER HEAD BOLT DONGFENG VALVE COVER BOLT DONGFENG DONG FENG CASING BOLT FLYWHEEL CASE DONGFENG DONG FENG MANIFOLD BOLT DONGFENG DONG FENG ROCKER ARM BOLT DONGFENG DONG FENG THERMOSTAT BOLT DONGFENG DONG FENG OIL PUMP BOLT DONGFENG DONG FENG FLYWHEEL BOLT DONGFENG DONG FENG RETURN BOLT DONG FENG DONG FENG SUPPORT BOLT DONGFENG DONG FENG PAN BOLT DONGFENG DONG FENG FAN DRIVE BOLT DONGFENG DONG FENG ADJUSTING BOLT DONGFENG DONG FENG CAMSHAFT BOLT DONGFENG DONG FENG INJECTOR BOLT DONGFENG DONG FENG CONNECTING ROD BOLT DONGFENG DONG FENG PULLEY BOLT DONGFENG DONG FENG BOLT ECU CONTROL UNIT DONGFENG DONG FENG BOLT VALVE DONGFENG DONG FENG BOLT FITTING DONGFENG DONG FENG YOKE DONGFENG DONG FENG SHAFT ROCKER ARM AXLE DONGFENG DONG FENG PUSH SHAFT DONGFENG DONG FENG TIMING GEAR SHAFT DONGFENG DONG FENG FLYWHEEL RING DONGFENG DONG FENG FAN IMPELLER DONGFENG DONG FENG VIBRATION ISOLATOR DONGFENG DON G FENG VISCOUS CLUTCH DONGFENG FLUID CLUTCH DONGFENG DONG FENG CRANKSHAFT MAIN INSERTS CRANKSHAFT DONGFENG DONG FENG CONNECTING ROD INSERTS DONGFENG DONG FENG CAMSHAFT BUSHING DONGFENG DONG FENG BUSHING INJECTOR CASE DONGFENG DONG FENG CONNECTING ROD BUSHING DONGFENG DONG FENG NUT DONGFENG DONG FENG GENERATOR DONGFENG DONG FENG SLEEVE DONGFENG DONG FENG HEAD CYLINDER BLOCK cylinder head DONGFENG DONG FENG AIR PRESSURE SENSOR DONGFENG DONG FENG OIL PRESSURE SENSOR DONGFENG DONG FENG FUEL PRESSURE SENSOR DONGFENG DONG FENG TURBINE PRESSURE SENSOR DONGFENG DONG FENG OXYGEN SENSOR DONGFENG DONG FENG COLLECTOR SENSOR DONGFENG DONG FENG SPEED SENSOR DONGFENG DONG FENG CRANKSHAFT POSITION SENSOR DONGFENG DONG FENG CAMSHAFT POSITION SENSOR DONGFENG DONG FENG FUEL CONSUMPTION SENSOR DONGFENG DONG FENG SPEED SENSOR DONGFENG DONG FENG TEMPERATURE SENSOR DONGFENG DONG FENG DAMPER RESONANCE DAMPER DONGFENG DONG FENG WIRING HARNESS WIRING DONGFENG DONG FENG PLUG DONGFENG PLUG DONG FENG CASE FLYWHEEL HOUSING DONGFENG DONG FENG CASE HOUSING DONGFENG ROCKER ARM HOUSING DONGFENG TIMING GEAR CASE DONGFENG DONG FENG IGNITION COIL DONGFENG DONG FENG VALVE INLET DONGFENG DONG FENG VALVE EXHAUST DONGFENG DONG FENG EGR VALVE EGR DONGFENG DONG FENG HEAT EXCHANGER OIL COOLER VALVE DONGFENG DONG FENG FUEL RACK RAMP VALVE DONGFENG DONG FENG DISCHARGE VALVE DONGFENG D ONG FENG BYPASS VALVE DONGFENG DONG FENG CHECK VALVE DONGFENG DONG FENG PRESSURE REGULATOR VALVE DONGFENG DONG FENG VALVE REDUCTION DONGFENG DONG FENG Pump pump VALVE DONGFENG DONG FENG CRANKSHAFT CRANKSHAFT DONGFENG DONG FENG Oil scraper caps DONGFENG DONG FENG RING CASES DONGFENG DONG FENG PISTON RINGS DONGFENG DONG FENG RING PISTON PIN STOPPER DONGFENG DONG FENG RING SEAL DONGFENG DONG FENG INTAKE MANIFOLD DONGFENG DONG FENG EXHAUST MANIFOLD DONGFENG DONG FENG KIT SET OF GASKETS ENGINE REPAIR KIT DONGFENG DONG FENG AIR COMPRESSOR DONGFENG DONG FENG ROCKER ARM OF INLET EXHAUST VALVE DONGFENG DONG FENG ROCKER ARM INJECTOR DONGFENG DONG FENG CROSSBOW DONGFENG DONG F ENG FAN BRACKET DONGFENG DONG FENG GENERATOR BRACKET DONGFENG DONG FENG FILTER BRACKET DONGFENG DONG FENG INJECTOR BRACKET DONGFENG DONG FENG ENGINE COVER REAR FRONT DONGFENG DONG FENG VALVE COVER DONGFENG DONG FENG FLYWHEEL DONGFENG DONG FENG VALVE GUIDE DONGFENG DONG FENG POWER PUMP DONGFENG DONG FENG VACUUM PUMP DONGFENG DONG F ENG WATER PUMP DONGFENG DONG FENG OIL PUMP DONGFENG DONG FENG BOOST PUMP DONGFENG DONG FENG PUMP HIGH PRESSURE FUEL Pump DONGFENG DONG FENG FUEL PUMP LOW PRESSURE PIPE DONGFENG DONG FENG FUEL TRANSFER PUMP DONGFENG DONG FENG FUEL PUMP PUMP DONGFENG DONG FENG GEAR PUMP DONGFENG DON G FENG BELT TENSIONER BELT TENSIONING MECHANISM DONGFENG DONG FENG FAN SUPPORT DONGFENG DONG FENG GENERATOR SUPPORT DONGFENG DONG FENG ROCKER ARM SUPPORT ROCKER ARM DONGFENG DONG FENG SUPPORT OF PUSHERS DONGFENG DONG FENG PISTON PIN DONGFENG PISTON DONGFENG DONG FENG AIR DUCT DONGFENG DONG FENG PLUNGER DONGFENG DONG FENG PLUNGER PAIR DONGFENG DONG FENG CRANK PAN DONGFE NG DONG FENG BEARING DONGFENG DONG FENG PISTON PISTON GROUP CYLINDER GROUP DONGFENG DONG FENG CYLINDER HEAD GASKET DONGFENG DONG FENG TIMING GEAR CASE GASKET DONGFENG DONG FENG VALVE COVER GASKET DONGFENG DONG FENG MANIFOLD GASKET DONGFENG DONG FENG COMPRESSOR GASKET DONGFENG DONG FENG ROCKER ARM BODY GASKET THERMOSTAT HOUSING GASKET DONGFENG DONG FENG CAMSHAFT COVER GASKET DONGFENG DONG FENG PUSHTER COVER GASKET DONGFENG DONG FENG OIL FILLER GASKET NECK DONGFENG DONG FENG HEAT EXCHANGER OIL COOLER GASKET DONGFENG DONG FENG PUMP GASKET DONGFENG DONG FENG FRONT COVER GASKET DONGFENG DONG FENG PAN GASKET DONGFENG DONG FENG SOLENOID GASKET ELECTRICAL SOLENOID VALVE DONGFENG DONG FENG TUBE GASKET DONGFENG DONG FENG TURBOCHARGER TURBINE GASKET TURBOCHARGER DONGFENG DONG FENG GASKET SEAL DONGFENG DONG FENG DONGFENG VALVE SPRING DONG FENG CYLINDER HEAD SPRING DONGFENG DONG FENG RAIL FUEL RAIL DONGFENG DONG FENG CAMSHAFT DONG FENG CAMSHAFT DONG FENG INJECTOR SPRAYER DONGFENG DONG FENG FAN BELT DONGFENG DONG FENG GENERATOR BELT DONGFENG DONG FENG DRIVE BELT DONGFENG DONG FENG TENSIONER ROLLER TENSIONER DONGFENG DONG FENG INTERMEDIATE ROLLER DONGFENG DONG FENG PUSHER ROLLER DONGFENG DONG FENG SEAL CUFF DONGFENG DONG FENG CRANKSHAFT EPILON REAR DONGFENG DONG FENG CRANKSHAFT EPILON FRONT DONGFENG DONG FENG EPILON WATER PUMP DONGFENG DONG FENG OIL PUMP SEAL DONGFENG DONG FENG FRONT COVER SEAL DONGFENG DONG FENG THERMOSTAT SEAL DONGFENG DONG FENG PULLEY SEAL DONGFENG DONG FENG BREATHER DONGFENG DONG FENG SPARK PLUG DONGFENG DONG FENG VALVE SEAL DONGFENG DONG FENG SOLENOID SOLENOID VALVE DONGFENG DONG FENG STARTER DONGFENG DONG F YENG DONGFENG VALVE CLEANER DONGFENG VALVE SPRING PLATE DONGFENG DONG FENG HEAT EXCHANGER OIL COOLER DONGFENG DONG FENG THERMOSTAT DONGFENG DONG FENG VALVE PUSHER DONGFENG DONG FENG CAMSHAFT PUSHER DONGFENG DONG FENG TUBES PIPING KIT DONGFENG DONG FENG RETURN PIPE DONGFENG DONG FENG RETURN PIPE DONGFENG DONG FENG RETURN PIPE WASHING DONGFENG DONG FENG OIL SUPPLY PIPE DONGFENG DONG FENG FUEL SUPPLY PIPE DONGFENG DONG FENG BREATH PIPE DONGFENG DONG FENG OIL DRAIN PIPE DONGFENG DONG FENG FUEL PIPE DONGFENG DONG FENG TURBINE TURBOCHARGER TURBOCHARGER DONGFENG DONG FENG AIR FILTER DONGFENG DONG FENG GAS FILTER DONGFENG DONG FENG HYDRAULIC FILTER DONG FENG DONG FENG OIL FILTER DONGFENG DONG FENG BREATH FILTER DONGFENG DONG FENG COOLING SYSTEM FILTER DONGFENG DONG FENG FUEL FILTER DONGFENG DONG FENG ANTICIPATE FILTER DONGFENG DONG FENG PISTON COOLING NOZZLE DONGFENG DONG FENG FUEL INJECTOR DONGFENG DONG FENG CLAMP CLAMP DONGFENG DONG FENG CONNECTING ROD DONGFENG DONG FENG WASHER DO NGFENG DONG FENG CRANKSHAFT GEAR DONGFENG DONG FENG CAMSHAFT GEAR DONGFENG DONG FENG COMPRESSOR GEAR DONGFENG DONG FENG PUMP GEAR DONGFENG DONG FENG INTERMEDIATE GEAR DONGFENG DONG FENG TACHOMETER GEAR DONGFENG DONG FENG INJECTION GEAR DONGFENG DONG FENG FAN PULLEY DONGFENG DONG FENG PULLEY CRANKSHAFT DONGFENG DONG FENG PUMP PULLEY DONGFENG DONG FENG HOSE DONGFENG DONG FENG STUD DONGFENG DONG FENG KEY DONGFENG PIN DONG FENG PUSHER ROD DONGFENG DONG FENG FITTING CONNECTOR CARROT NOZZLES DONGFENG DONG FENG

Delivery of spare parts to DONGFENG in Russia and CIS countries:

Abakan, Adler, Azov, Alexandrov, Aleksin, Almetyevsk, Anapa, Angarsk, Anzhero-Sudzhensk, Arzamas, Armavir, Artyom, Arkhangelsk, Astrakhan, Achinsk, Apatity, Arsenyev, Asbest, Balakovo, Balashikha, Barnaul, Bataysk, Belgorod, Berdsk, Berezniki, Biysk, Blagoveshchensk, Bratsk, Bryansk, Balakhna, Balashov, Belebey, Belovo, Belogorsk, Beloretsk, Belorechensk, Berezovsky, Birobidzhan, Bor, Borisoglebsk, Borovichi, Bugulma, Budennovsk, Buzuluk, Buynaksk, Bodaibo, Borovsk, Buguruslan, Veliky Novgorod , Vladivostok, Vladikavkaz, Vladimir, Volgograd, Volgodonsk, Volzhsky, Vologda, Voronezh, Velikiye Luki, Verkhnyaya Pyshma, Vidnoye, Volsk, Vorkuta, Voskresensk, Votkinsk, Vsevolozhsk, Vyborg, Vyksa, Vyazma, Verkhnyaya Salda, Grozny, Gatchina, Gelendzhik, Georgievsk, Glazov, Gorno-Altaisk, Gubkin, Gudermes, Gukovo, Gus-Khrustalny, Gai, Gubkinsky, Derbent, Dzerzhinsk, Dimitrovgrad, Dolgoprudny, Domodedovo, Donskoy, Dubna, Dobryanka, Dyurtyuli, Evpatoria, Ekaterinburg, Yelets, Essentuki, Yegoryevsk, Yeysk, Elabuga, Zheleznogorsk, Zhukovsky, Zhigulevsk, Zlatoust, Zarechny, Zelenogorsk, Zelenodolsk, Zarinsk, Ivanovo, Izhevsk, Irkutsk, Ivanteevka, Izberbash, Iskitim, Ishim, Ishimbay, Yoshkar-Ola, Kazan, Kaliningrad, Kaluga, Kamensk-Uralsky, Kamyshin, Kaspiysk, Kemerovo, Kerch, Kirov, Kislovodsk, Kovrov, Kolomna, Komsomolsk-on-Amur, Kopeisk, Korolev, Kostroma, Krasnogorsk, Krasnodar, Krasnoyarsk, Kurgan, Kursk, Kyzyl, Kamensk-Shakhtinsky, Kansk, Kineshma, Kirishi, Kirovo-Chepetsk, Kiselevsk, Kislovodsk, Klin, Klintsy, Kogalym, Kotlas, Krasnokamensk, Krasnokamsk, Krasnoturinsk, Kropotkin, Krymsk, Kstovo, Kuznetsk, Kumertau, Kungur, Kachkanar, Kovdor, Korolev, Koryazhma, Kostomuksha, Kurchatov, Lipetsk, Lyubertsy, Labinsk, Leninogorsk, Leninsk-Kuznetsky, Lesosibirsk, Liski, Lobnya, Lysva, Lytkarino, Labytnangi, Langepas, Lyantor, Magadan, Magnitogorsk, Maykop, Makhachkala, Miass, Moscow, Murmansk, Murom, Mytishchi, Mezhdurechensk, Meleuz, Mineralnye Vody, Minusinsk , Mikhailovka, Mikhailovsk, Michurinsk, Megion, Mirny, Monchegorsk, Muravlenko, Myski, Naberezhnye Chelny, Nazran, Nalchik, Nakhodka, Nevinnomyssk, Neftekamsk, Nefteyugansk, Nizhnevartovsk, Nizhnekamsk, Nizhny Novgorod, Nizhny Tagil, Novokuznetsk, Novokuibyshevsk, Novomoskovsk, Novo Russian, Novosibirsk, Novocheboksarsk, Novocherkassk, Novoshakhtinsk, Novy Urengoy, Noginsk, Norilsk, Noyabrsk, Nazarovo, Naro-Fominsk, Neryungri, Novoaltaisk, Novotroitsk, Novouralsk, Nyagan, Nadym, Naryan-Mar, Neftegorsk, Nizhniye Sergi, Novodvinsk, Nogliki, Obninsk, Odintsovo, Oktyabrsky, Omsk, Orel, Orenburg, Orekhovo-Zuevo, Orsk, Ozersk, Otradny, Penza, Pervouralsk, Perm, Petrozavodsk, Petropavlovsk-Kamchatsky, Podolsk, Prokopyevsk, Pskov, Pushkino, Pyatigorsk, Pavlovo, Pavlovsky Posad, Polevskoy, Cool , Pechora, Pokachi, Ramenskoye, Reutov, Rostov-on-Don, Rubtsovsk, Rybinsk, Ryazan, Revda, Rzhev, Rossosh, Raduzhny, Salavat, Samara, St. Petersburg, Saransk, Saratov, Sevastopol, Severodvinsk, Seversk, Sergiev Posad, Serpukhov, Simferopol, Smolensk, Sochi, Stavropol, Stary Oskol, Sterlitamak, Surgut, Syzran, Syktyvkar, Salsk, Sarapul, Sarov, Svobodny, Serov, Sertolovo, Sibay, Slavyansk-on-Kuban, Solikamsk, Solnechnogorsk, Sosnovy Bor, Stupino, Salekhard, Satka, Sayanogorsk, Svetly, Svetogorsk, Sosnogorsk, Strezhevoy, Taganrog, Tambov, Tver, Togliatti, Tomsk, Tula, Tyumen, Timashevsk, Tikhvin, Tikhoretsk, Tobolsk, Troitsk, Tuapse, Tuymazy, Tarko-Sale, Ulan-Ude, Ulyanovsk, Ussuriysk, Ufa, Urus-Martan, Usolye-Sibirskoye, Ust-Ilimsk, Ukhta, Udachny, Udomlya, Urai, Usinsk, Uchaly, Feodosia, Fryazino, Khabarovsk, Khasavyurt, Khanty-Mansiysk, Khimki, Cheboksary, Chelyabinsk, Cherepovets, Cherkessk, Chita, Tchaikovsky, Chapaevsk, Cheremkhovo, Chernogorsk, Chekhov, Chistopol, Chernushka, Shakhty, Shadrinsk, Shali, Shuya, Shelekhov, Shchekino, Shchelkovo, Elektrostal, Elista, Engels, Yuzhno-Sakhalinsk, Yurga, Yakutsk, Yanaul, Yalta, Yaroslavl.