Characteristics of Chinese diesel walk-behind tractors Zirka 41 and 105

User manual

Keep the documents for the walk-behind tractor during the entire period of operation. Select engine oil and lubricants as recommended in your engine manual. For old equipment older than 5 years, perform scheduled engine maintenance once a year.

First launch and run-in

Perform the first start of the walk-behind tractor when the device is assembled and ready for use. Follow the instructions for assembly. Heavy walk-behind tractors are often sold already assembled and even run-in. The minimum break-in duration is 10 hours, the maximum is 20.

Maintenance

Oil: according to the season, and also based on the type of engine cooling and the engine itself. Any manufacturer.

The frequency of oil changes is at least once every 50 operating hours; it can be changed more often, especially in conditions of continuous operation.

Gasoline grade AI95/AI92, diesel fuel - settled for 48 hours.

Basic malfunctions and their elimination

Basic malfunctions of Zirka and methods for eliminating them:

• The device does not start. Possible reason: low fuel and oil. Remedy: Fill the tank with fuel.
• The engine gets very hot. Remedy: Reduce the load and engine speed. The cause of overheating may be the lack of coolant. If necessary, add fluid to the cooling reservoir.
• Black smoke comes out of the exhaust pipe. Possible cause: oil is burning. Remedy: clean all external surfaces of oil, do not add more oil than normal.

Clean the air filter regularly and check the condition of the fuel filter.

Walk-behind tractors "Zirka": start-up and operation

Proper introduction of a walk-behind tractor into field work is the key to less wear and tear, which means savings on repairs and spare parts.
Before starting:

1. The walk-behind tractor is filled with fuels and lubricants;
2. Measure the tire pressure and, if necessary, pump it up with a compressor to the mark specified in the instructions for the specific model;
3. Move the clutch lever to the disengaged position;
4. Open the fuel tap;
5. The knob, which is responsible for selecting the speed mode, is moved to the “neutral” mark;
6. The throttle valve is relaxed, and the lever itself is moved to the starting location;
7. After this, they proceed to turn on the device.

Absolutely new, unused Zirka walk-behind tractors must be broken in. According to the manufacturer’s standards, running in these walk-behind tractors is carried out in 3 stages:

1. Idle operation - its duration depends on the number of gears. It should work for half an hour at each forward speed, and for 15 minutes at the existing reverse speeds. For 8-speed cars, this stage should take 4.5 hours;
2. Operation under a load reduced by a third - designed for 6 or 5 hours (for walk-behind tractors with 3 forward modes). Its peculiarity is that reverse speeds are not used;
3. Application with half load - for 8-speed units it will take 12 hours. Run-in of the initial gears is carried out only with a rototiller, the immersion of which into the soil is determined by its density. High speeds are only tested with a trailer on roads with different types of surfaces.

After the break-in is completed, change the engine oil and begin plowing.

Diesel models

Zirka GT76D02

The Zirka GT76D02 walk-behind tractor is a diesel model designed to perform various field work. The power plant of the unit has a power of 7.5 hp. and two power take-off shafts that allow the use of any attachments.

Wheels size 4.00-10 have a textured tread that can easily overcome off-road conditions. The hubs of this model are two-position, which allows you to adjust the width of the row.

Zirka SH-41T

The Zirka SH-41T walk-behind tractor (diesel) is a representative of the low-power series, because the engine power is only 4 hp. The model is perfect for work on a farm with a small plot of land.

Low fuel consumption of 0.95 l/h saves time allotted for refueling and the owner’s material resources. Air cooling is provided, which significantly reduces the risk of breakdowns in the mechanism. The model weighs only 87 kg, making it easy to transport.

Zirka IZ 105 E

The Zirka IZ 105 E walk-behind tractor is designed for professional work and is capable of handling large areas. Engine power equal to 6 hp. enough to treat an area of ​​up to 1 hectare.

Zirka LX 1090 D

The diesel walk-behind tractor Zirka LX 1090 D is a representative of the professional class, because its engine power of 9.5 hp is enough for a large plot of up to 1 hectare. Thanks to water cooling, there will be no problems with the motor even in very hot weather.

The walk-behind tractor is considered the latest generation model and is equipped with a six-speed gearbox. When using a trailer or cart, the unit can easily replace a vehicle and transport goods. The presence of a headlight makes it possible to use the walk-behind tractor at night.

Zirka LX 2093D

The Zirka LX 2093D walk-behind tractor is a brother of the previous model and is part of the line of professional models thanks to a powerful engine with 9 horsepower. This model only has air cooling. The most appropriate use of this device will be on an area of ​​up to 2 hectares. Thanks to the gear reducer with disc clutch, the walk-behind tractor will confidently process mail. Rubber wheels with significant tread can cope with any off-road conditions. This model has only 2 forward and 1 rear speeds, but this also affects its maneuverability.

Zirka GN 151 E

The Zirka GN 151 E walk-behind tractor is a heavyweight in its line, because its weight is 505 kg. Thanks to a powerful engine with 15 horses, the owner will not feel tired while working, as the unit can easily cope with both cargo transportation and soil cultivation.

The presence of an electric starter makes it easier to start the engine, but it is possible to start it manually. The model is equipped with a halogen headlight, which is useful in the dark. Fuel consumption is 2.9 l/h.

Zirka SH 61

The Zirka SH 61 walk-behind tractor cannot be called a baby, even though the engine power is 6 hp. This model has significant dimensions and weighs 210 kg. Its ability to reach speeds of up to 12 km/h allows it to be used as a vehicle.

Zirka IZ 135 E

The Zirka IZ 135 E walk-behind tractor is one of the most popular models, as it has relatively small dimensions and a powerful engine with 9 horsepower. A reliable gearbox with a worm gear is designed for heavy loads, so with this unit you can plow the soil, transport a load, or set up a potato digger for harvesting.

Consumption is 1 l/h, and with a 5-liter fuel tank, there will be no need for numerous refuelings. The model is equipped with manual engine start and electric starter, giving the owner the opportunity to choose.

Attachments

The use of additional equipment not only increases the capabilities of the unit, but also makes it much easier for the owner to carry out various works. Thanks to the presence of a power take-off shaft in Zirka walk-behind tractor models, the use of attachments does not present any difficulties.

Listed below are all types that are used with Zirka walk-behind tractors:

• The adapters are designed for comfortable work as you can sit on them. Thanks to the pneumatic wheels, movement on this device is pleasant and convenient.
• Mills, as a rule, come complete and are designed for cultivating soil of any complexity. The photo shows how the cutters are assembled.

• Harrows - used to break up large pieces of earth that form after plowing. The working width may vary.
• Grousers are essential for use on sticky soil because they make it easier to pass.
  They are selected based on the size of the walk-behind tractor and its weight. Harrows Grousers (axle diameter 32 mm) Rakes
• A rake is used for raking hay and grass.
• A wood splitter is a fairly specialized piece of equipment, but with its help you can not only save energy, but also save time spent on preparing firewood.
• Mowers are popular equipment as they are designed for cutting grass.
  There are 2 types: rotary and segmental. Configurations and sizes vary. Segment mowers have two rows of pointed teeth that move in a horizontal plane. They are capable of cutting not only grass, but also small shrubs, but they only work on flat areas. Rotary ones operate by three knives that rotate and cut the grass. They can also work on inclined surfaces. The rotary mower is designed in several variations to provide the best attachment to a specific model. Segment mower for walk-behind tractor Zirka LX 2064 G Rotary mower (PTO - key) Wood splitter for walk-behind tractor (65 mm splitting ax)
• A potato digger makes harvesting root crops easier. The device lifts the ground and separates the root crops, leaving them intact away from the rut.
• A plow shovel or snow blower will be useful in areas with significant snowfall to help clear the snow.
  Snow blower
• Hillers make it easier to create beds and ridges on them.
• The plow is used in those areas of the soil where tillers cannot cope.
  Cuts the soil and turns it over. Plowing occurs as follows: the first rut is made, then one wheel is placed in it, and the plow is lowered into the ground. Thus, the second track buries the first. Using this device, you can not only lay furrows for further planting of seedlings, but also as channels for draining water. With a plow, preparing the soil for winter will be much faster. Standard plow with Okuchnik hitch
• A water pump is used to pump water.
• Trailers turn the walk-behind tractor into a vehicle and allow you to transport various loads weighing up to 800 kg.
• Weights help add additional weight to the walk-behind tractor when weeding, allowing the operator to apply minimal effort.
  Trailer Pump Weights

Walk-behind tractor "ZIRKA" SH-61

A multifunctional device capable of performing several agricultural tasks at once: harrowing, discing, loosening, cultivating, hilling crops, cutting hay and digging up potatoes and other tuber crops.
Ideal for those farms where purchasing a tractor is not economically feasible and manual labor would be unjustified. According to the operating instructions, it can be used regardless of soil type and time of year, which eliminates equipment downtime. Advantages:

• 4-stroke engine powered by diesel;
• thermal protection of the power mechanism - a radiator with hydrocooling prevents overheating and failure;
• halogen flashlight, which simplifies field work in poor visibility conditions;
• the ability to connect any electrical appliances with a power of up to 0.06 kW to the headlight generator;
• 8-speed mixed gearbox;
• lockable differential;
• the use of ring brakes and a single-disc friction clutch;
• transmission of mechanical energy through V-belt transmission;
• wheel travel with large tires.

Performance indicators:

• Power – 7 hp;
• Plowing – 75/19 cm;
• Diesel tank/consumption – 5/1.25 l;
• Dimensions – 2.18 x 0.89 x 1.25 m;
• Weight – 210 kg.

Walk-behind tractor "Zirka" GT90D04

One of the powerful Zirka walk-behind tractors in the gasoline series. Suitable for processing large plots of land and for large agricultural firms that need to replace manual labor all year round. It has a distinctive external design and reliable internal working parts for durable operation. In a matter of minutes it can be equipped with different types of auxiliary attachments - plows, harrows, grousers, flat cutters. With its impressive weight of almost 300 kg, it develops speeds of up to 20 km/h. With additional re-equipment it turns into a vehicle capable of transporting not only the operator, but also luggage.

Advantages:

• 1-cylinder 4-stroke engine running on high-octane gasoline and cooled by an air turbine;
• double strat - the consumer independently chooses whether to use a manual or electric starter;
• reduced number of turns on the site due to the capture of a wide strip of 1 m;
• gear transmission that receives power through a differential (lockable);
• the ability to set yourself a comfortable plowing pace with one of 8 speeds.

Technical properties:

• Power – 9 hp;
• Gasoline consumption – 1.8 l/h;
• Gas tank – 5.5 l;
• Loosening depth – 19 cm;
• Dimensions – 2.17 x 0.85 x 1.15 m.

Types and models

Today, the Chinese manufacturer produces two types of Zirka walk-behind tractors: with gasoline and diesel engines. In addition, agricultural products are represented by various models; they differ in design and technical characteristics. The most popular modifications, which are in great demand and have received positive reviews from customers, include several models.

Zirka LX 1090D

This walk-behind tractor is classified as a heavy type of equipment. Its design is thought out by the manufacturer to the smallest detail, so it has high-quality assembly and is endowed with maximum functionality. The unit is equipped with an R190N diesel engine, it is equipped with a gear pump and a water cooling system. This model has a balanced design, this is explained by the special placement of the main components and the presence of a modernized frame. In addition, the device is equipped with a 12 V electric generator, which is responsible for powering all electrical appliances and built-in headlights.

Important: Replacing and installing kingpins on a KamAZ vehicle

The engine power of the model is 9.5 liters. s., the tank holds 5.5 liters of fuel, the consumption of which is small - 1.6 l/h. During soil cultivation, the maximum depth is 25 cm, the plowing width can reach up to 75 cm. The weight of the device without attachments is 230 kg. This device can be used to plow the ground, mow grass, hill up beds, and collect and transport crops. In one approach, such a walk-behind tractor allows you to cultivate a land plot of up to 3 hectares.

Zirka IZ-105E

This is a mid-price class equipment, the advantages of which are considered to be low diesel fuel consumption, compactness and excellent maneuverability. The main component of the design is the SH186F four-stroke diesel engine with an additional air cooling system. The drive in the design is a disc clutch. The fuel tank holds up to 3.5 liters of diesel fuel, the engine power is 6 liters. pp., diesel consumption does not exceed 0.49 l/h. Using a walk-behind tractor, you can plow an area 105 cm wide with a soil depth of 30 cm.

Zirka IZ-135E

A walk-behind tractor of this modification is most often chosen by owners of small plots of land for cultivating any type of soil, harvesting crops, transporting cargo and clearing the area of ​​debris and snow. The manufacturer produces a unit with a Kama diesel engine and a worm gearbox. The unit is designed for severe operating conditions and increased loads. The advantage of the model is considered to be good maneuverability, silent operation and good cross-country ability. As for the technical characteristics, the engine performance in the walk-behind tractor is 9.2 liters. s., the fuel tank holds 5.5 l, the plowing width does not exceed 135 cm, the tillage depth is 30 cm, the fuel consumption is 1.2 l/h.

Zirka GT76D

This unit is usually suitable for processing areas whose area does not exceed 2 hectares. The factory equipment includes a four-stroke diesel engine; it has a working life of 12,000 hours. In addition, the device is equipped with a splined and keyed power take-off, thanks to which various types of attachments can be installed on the walk-behind tractor. Technical features of the walk-behind tractor: diesel fuel consumption 1.6 l/h, engine power 7.8 l. s., fuel tank volume 3.5 l. The unit can plow areas 114 cm wide, with a plowing depth of 30 cm.

Zirka LX 2040D

This modification is characterized by good assembly, increased maneuverability and a long service life. Since the design of the walk-behind tractor is simple, if the equipment fails, the owner will be able to repair it himself. The manufacturer produces equipment with a Kama 179F diesel engine with a power of 4.3 liters. With. The weight of the walk-behind tractor without additional equipment is 80 kg, fuel consumption during one hour of operation does not exceed 0.6 liters. This technique can cultivate soil up to 30 cm deep, while the plowing width can be no more than 75 cm.

Purpose

The main purpose of this walk-behind tractor is to work in rural conditions and provide assistance in small agricultural plots. Moreover, the concept of “small” is relative here, because the area of ​​the plots can be up to 5 hectares. And yet, it must be admitted that this technique has become most widespread in small and fractional areas.

In such conditions, using a compact walk-behind tractor is much more convenient than using a tractor. In addition to its compact dimensions, the key advantages of the Zirka-105 compared to tractors include high fuel efficiency. After all, such equipment does not need to have a powerful motor.

Users of Zirka-105 walk-behind tractors, as practice shows, highly appreciate its advantages. In addition, the equipment can be equipped with various devices that are designed to make the walk-behind tractor more efficient and durable. Zirka 105 is a universal agricultural machinery, and we must admit that compared to its competitors it is not the most affordable choice. The fact is that this model is located in the middle price category. However, with many different modifications and additions, the Zirka 105 offers excellent value for money. The final cost was negatively affected not only by the cost of the model, but also by the expensive delivery of spare parts from China. But even taking this into account, the walk-behind tractor has a very competitive price, especially compared to its more famous analogues.

Zirka-105 will be indispensable in almost any area of ​​agricultural activity - especially where a tractor cannot pass. The performance of the walk-behind tractor will be impressive. The maximum tillage depth for which Zirka-105 is designed is 30 cm.

At the same time, the width of the working strip reaches 1.4 meters. Of course, you also need to pay attention to the type of attachment and the capabilities of the motor. It is noteworthy that the lightest models received a productivity of 1.5 hectares. Please note that the assessment of the performance of a walk-behind tractor is influenced by several factors - the performance of the driver, the frequency of maintenance, the speed of movement and the processing of the earth's surface.

Examples include the GT76D02 (E) and GT90D04 (E) models, equipped with 7.5 and 9 hp engines. With. respectively. According to official specifications, for these modifications, the milling area should not exceed 0.59 - 1.33 hectares per hour.

Features of Zirka walk-behind tractors

Due to the variety of models, Zirka motor cultivators are able to work in any conditions, with all types of soil, and also completely replace human labor in cultivating the soil and harvesting crops.

All models of Zirka brand walk-behind tractors have the following advantages:

1. Certified production of each element (quality control at all stages).
2. The engines of each model are powerful but economical.
3. The products are developed taking into account all possible conditions (climate, soil density, geography), therefore they are universal.
4. Each product unit can be equipped with various types of attachments.
5. The average price range provides an army of fans among farmers and gardeners.

Also, the features of the model range of walk-behind tractors of the Zirka brand include safety when working with equipment. Therefore, each model has an emergency stop function.

This type of walk-behind tractor has its pros and cons.

How to adjust the Zirka walk-behind tractor?

Adjustment is the main task of the commissioning cycle for any walk-behind tractor. It is produced in the following sequence:

1. Check the tension of the V-belt drive - if the walk-behind tractor has 2 V-belts, their size should be the same. Otherwise:

• Unscrew the 4 bolt ties located under the frame;
• Find the adjusting screw shown in the figure and turn it to change the alignment of the motor;

At the same time, monitor the degree of tension of the belts, which are fixed by tightening the bolts.

1. Adjust the clutch. If the distance between the release bearing and the 3 release levers is not the same (or deviates from the parameter between 0.3-0.5 mm), proceed with adjustment - change the position of the hex nut on the rod;

1. Check the serviceability of the brake - if the walk-behind tractor rolls on a slope with the brake lever pressed, you need to:

• Turn off the brake;
• Tighten the adjusting nut until the pressure spring touches the hinge;
• Move the handle to the braking position and check the operation of the system.

Service

The key point in using a walk-behind tractor is to run it in after purchase or after long-term inactivity. Thanks to high-quality running-in, the parts are lubricated and run-in, ensuring a long service life of the unit.

Initially, the unit idles for 15 minutes with possible gas leaks. For the next 4 hours, you are allowed to use the walk-behind tractor with minimal load. This means that you only need to attach the wheels and move the walk-behind tractor. Additional equipment cannot be attached at this time. Only after 8 hours of running-in can the device be used at full capacity.

Important! After the break-in is completed, the engine oil is completely changed. After each work shift, it is advisable to carry out minimal maintenance, which consists of the following actions:

After each work shift, it is advisable to carry out minimal maintenance, which consists of the following actions:

• Wash the walk-behind tractor and at the same time check for oil or fuel leaks.
• Check the condition of all fasteners.
• Check the oil level and, if the model matches, the coolant level. Remember that in winter the coolant is not used and is drained.
• Check the belt tension.
• Clean or replace the air filter after 8-50 hours of operation.

Recommended lubricants:

• Oil: type HL-11 in summer, type NS-8 in winter.
• Liquid lubricant: type HL-30 in summer and type HL-20 in winter.

1. If the engine does not start, it is necessary to: check the presence of fuel and sparks in the spark plug, clean the air filter and fuel tank.
2. If the engine gets very hot, the reason for this may be a lack of oil, clogging of the ventilation, engine or muffler. In this case, it is necessary to clean the parts and refill with oil.
3. If noise occurs in the gearbox, the cause must be sought in the absence of oil in the gearbox and faulty bearings.

Review of the Zirka walk-behind tractor

The Zirka walk-behind tractor is used for plowing the soil, developing trenches, cultivating, sowing grain and harrowing the land. It can work in any area: in the garden, greenhouse, vegetable garden, in mountainous areas.

The Zirka walk-behind tractor is small in size, light in weight, and convenient for storage and transportation. The motor cultivator consumes a small amount of fuel. The mechanism is equipped with a four-stroke engine with a water and air cooling system.

The engine has manual and electric ignition and an automatic decompressor, which reduces the load at the start of movement, which determines the high performance of this machine. If you carry out regular technical inspections and follow the rules for caring for the walk-behind tractor, the service life of the mechanism will be quite long.

All parts of the motor cultivator are made of impact-resistant materials that are not subject to corrosion and deformation. The mechanism can operate in any climate zone and under any weather conditions.

Various attachments have been created for the machines on the walk-behind tractor, which allows these models to be used for various agricultural work. With the help of a plow, the mechanism plows the ground, and with the help of a cart it transports loads or tools. A snow blower will help clear paths of snow in winter. Thus, the cultivator is a multifunctional mechanism with a wide range of actions.

Important TOP 5 modifications of the MAZ-6303 truck from the Minsk Automobile Plant

The unit is equipped with a device for unlocking one of the wheels. This ensures a small turning radius, which is convenient when performing work in a small area using mounted parts.

Controlling the motor cultivator is not difficult and is carried out using handles that allow you to move the machine in 4 directions.

Motoblock "Zirka" IZ-105

Medium-power walk-behind tractor, ideal for home use. It has a well-balanced design that can be operated even by a person without special training. With its maneuverability and cross-country ability, it is indispensable in areas with complex topography and on sloped land.

Advantages:

• 4.4 kW air-cooled diesel engine, consuming about 500 ml of diesel per hour;
• gear reducer with 3 speeds – 2 forward and 1 rear;
• spacious gas tank - 3.5 liters, which is enough for one work shift;
• large pneumatic wheels with deep tread capable of self-cleaning;
• the ability to plow from 75 to 105 cm of field in one pass;
• light weight – 105 kg.

Technical characteristics of the Zirka walk-behind tractor model 105

• engine power - 6 horsepower;
• four-stroke engine model - KM178F (FA), and manufacturer - KAMA;
• air cooling;
• 2 forward gears and one reverse;
• in width you can cultivate the soil at a distance of 75 to 105 centimeters, and in depth - from 8 to 30 centimeters. These are very good indicators, since you can adjust them depending on the type of work;
• the diesel tank has a volume of 3.5 liters;
• Fuel consumption is 0.47 liters per hour of active operation. Therefore, if you do light and short work, the consumption will be less;
• transmission - gear reducer;
• disc clutch;
• manual starter;
• equipment weight - 115 kilograms.

Before purchasing the equipment, you should carefully study the instructions. Diesel walk-behind tractors require careful and competent running-in, which will be the key to a long and reliable service life.

The capabilities of the Zirka walk-behind tractor are practically unlimited. You will be able to plow the ground, cultivate, harrow, make furrows, hill up plants, dig up potatoes, as well as mow grass, plant potatoes, transport goods, and much more. All this is possible thanks to the sufficient power of the machine, as well as a wide selection of attachments for it.

The body of the equipment is very durable and reliable, and all parts have a high resistance to intense wear. Thoughtful and convenient controls will allow you to quickly and efficiently perform all types of work.

It also has disadvantages. So, for example, before each start you will have to set the decompression valve to the “start” position. This is indicated in the instructions. If you don't do this, your equipment may eventually fail. This is not always convenient and it is not always possible to remember this. Other manufacturers have an automatic valve.

However, despite the shortcomings, the Zirka walk-behind tractor turned out to be very powerful and practical. It is not very widespread here yet, but in the future, if prices are competitive, it will become very popular among farmers.

Walk-behind tractor "zirka" gn-151

Motoblock "ZIRKA" heavy series. Equipped with a reliable and high-performance diesel engine with active liquid cooling function. Unlike the previous ones, thanks to the electric starter it starts quickly even in sub-zero weather.

The presence of additional lighting and compatibility with a wide range of hanging devices make it a universal assistant all year round.

Advantages:

• powerful motor part with a gear reducer and a nominal capacity of 903 cm3;
• 8-position transmission with 6 forward gears;
• disc clutch;
• rational consumption of fuels and lubricants – equipment requires 2.8 liters of diesel per hour;
• possibility of differential locking;
• easy start with electric starter;
• increased gas tank volume for long work shifts;
• heaviness, which is compensated by pneumatic tires.

Specifications:

• Plowing (deep) – 20 cm;
• Processing in one passage – 1 m;
• Strength – 15 hp;
• Fuel tank – 7 l;
• Weight – 505 kg.

A wide range of

What can the Chinese offer us? The walk-behind tractor whose characteristics interest us is already well tested and popular; it is worth considering the range of its main parameters. The engine power of walk-behind tractors varies greatly. For summer cottages, economical models with gasoline engines from 4 liters are quite suitable. s., and for small farms professional models with a diesel engine from 6 liters will be relevant. With.

It is worth mentioning that the manufacturer produces models with the most powerful engines among analogues. For example, the model, the GN-151E walk-behind tractor, is equipped with a diesel engine with 15 “horses” on board, this is comparable to small agricultural tractors.

Walk-behind tractor "Zirka" GT76D

A universal model characterized by extensive functionality and excellent performance characteristics.
Thanks to the PTO, it can be aggregated with most attachments (hiller, rotary harrow, potato digger, etc.), which turn it not only into a mini tractor or mini-harvester, but also into a snow blower or motor pump. It is distinguished by its low maintenance, maneuverability and ease of adjustment, which will be within the power of an inexperienced or elderly person. Advantages:

• vertically localized engine with direct injection of diesel fuel;
• increased engine life with low energy intensity of production - 1 kW/h will require 288.3 g of diesel;
• impact-resistant plastic case with vibration and sound insulation properties;
• handles with rubber pads, adjustable in height;
• manual and electric start of the motor unit;
• 3-speed gearbox with reverse;
• chevron tread pattern for quick self-cleaning;
• bright halogen lamp.

Equipment characteristics:

• Traction - 7.5 hp;
• Fuel tank – 3.5 l;
• Snatchable strip (width/depth) – 110/30 cm;
• Dimensions – 174 x 98 x 105 cm;
• Weight – 128 kg.

Motoblock "Zirka" LX-1090 D

Diesel walk-behind tractor designed for use in medium and large agricultural firms. The design is powered by a 9.5 horsepower air-cooled engine. Suitable for cultivating dense and clay soils. Thanks to the front PTO with belt drive, the unit is equipped with all kinds of attachment adapters. The rear gear shaft allows you to operate a rototiller with a grip of up to 0.9 m and various cultivation depths. Impressive size and weight parameters make it possible to use the plow without additional weight and aggregation with a trailer with a carrying capacity of up to half a ton.

Peculiarities:

• 4-stroke single-cylinder engine SN 190N with a capacity of 573 cm3 with high traction potential and manual start;
• efficiency - the unit requires about 1.62 liters of diesel per hour of operation;
• 8-speed transmission with 2 reverse speeds;
• stable pneumatic wheels;
• reliable disc clutch;
• Capacious gas tank, a full filling of which is enough for 3 hours of non-stop operation.

Specifications:

• Passage width – 90 cm;
• Plowing depth – 19 cm;
• Dimensions – 2.17 x 0.85 x 1.15 m;
• Weight – 230 kg.

Motoblock “Zirka” LX 2040 D

Diesel walk-behind tractor from the Zirka brand, designed for small plots of land (up to 0.7 hectares).
The 4-stroke motor component, together with a multi-disc clutch and gearbox, can be operated for several hours in a row without overheating. Its service life of 3 thousand hours prevents rapid wear of spare parts. Peculiarities:

• 4-horsepower Kama diesel engine, which is cooled by air flow and started only in manual mode;
• labyrinth-type lower shaft oil seal fuses;
• control levers equipped with rubber vibration-damping pads;
• the presence of an emergency braking handle for the engine unit;
• gear transmission;
• minimal resource consumption;
• pneumatic wheels for unhindered driving on any type of surface;
• complete with 6-section cutter and protective discs.

Working properties:

• Thrust – 2.94 kW;
• Fuel capacity – 2.5 l;
• Lubrication sump – 800 ml;
• Diesel consumption – 300 ml/h;
• Cultivation width/depth – 88/16 cm;
• Dimensions – 1.65 x 0.62 x 1.1 m;
• Weight – 80 kg.

brief information

A significant part of the models are equipped with powerful engines and are designed for use on medium and large areas. A variety of attachments allows you to perform a wide range of agricultural work. The controls are very easy, thanks to which even women can operate the walk-behind tractor. All models feature reduced noise levels. With the latest options, one of the handles, marked in red, turns off the engine as soon as the operator releases it. This provides the necessary protection against accidents when working with such powerful equipment.

In the Zirka product line there are models with a gasoline engine, but more often the type of power plant is diesel. Most devices are equipped with Kama engines, the characteristics of which have aroused interest even among European manufacturers, who equip their much more expensive equipment with them. The engines have a long service life, so with proper technical care there should not be any problems with Zirk equipment. Repair of a walk-behind tractor may be needed sooner in case of operating errors or due to an accident. Spare parts for Zirka walk-behind tractors can always be purchased online.

To decide which model is better to go with, first of all, decide on the area on which you will have to work. The designation of devices of the latest modifications of the LX line contains 4 digits, of which the third indicates the engine power in hp. s., and the first is a class corresponding to the size of the area recommended for processing. At the same time, class 3 corresponds to a plot size of up to 50 acres, and class 2 is best chosen for an area of ​​0.2 to 1.5 hectares. The most powerful, class 1, is designed to work on areas of about three acres. A detailed technical description of any model can be found on the Internet.

Application area

Zirka walk-behind tractors are designed for a wide variety of workloads. Some models can cultivate the soil to a depth of 30 cm, while the width of the working strip can be up to 1.4 m, depending on the attachment and engine capabilities. Regarding the area of ​​cultivated land, the performance of the lightest models allows servicing plots of 1.

For example, the Zirka walk-behind tractors GT76D02(E) and GT90D04(E), according to the technical documentation, having on board 7.6- and 9-horsepower engines, respectively, are capable of milling an area from 0.59 to 1.33 hectares per hour. Do not forget about the transportation functions, which can be realized by equipping the device with a special cargo trailer. Zirka walk-behind tractors are capable of transporting from 250 kg to one and a half tons of cargo at speeds of up to 15 km/h.

Diesel models

An easy-to-use diesel model is the Zirka 105 walk-behind tractor. It runs on light diesel. Engine cooling is air.

The starter is installed manually. The power for a diesel engine is not the greatest - 6 hp, however, since it is intended primarily for household plots, it is quite enough.

The volume of its fuel tank is 3.5 liters. The walk-behind tractor is characterized by economical fuel consumption. The weight of the machine is about 115 kg, and the performance characteristics are as follows:

• • processing depth 16 cm;
• • processing width 1 m 5 cm;
• • maximum speed 9 km/h.

There are practically no breakdowns in this model of the Zirka walk-behind tractor, and therefore repairs, as a rule, are only required if the device is used incorrectly.

Another diesel walk-behind tractor Zirka 61 belongs to the class of professional heavy equipment for small-scale mechanization. Its power is 7 hp. This model has water cooling and a manual starter. The number of gears, like any professional model, is large - 6 forward and 2 rear, which is more than enough for comfortable use of this machine.

The depth of soil cultivation with a similar diesel-powered Zirka walk-behind tractor is quite large - 19 cm; and the width of the simultaneously cultivated strip is 75 cm. The weight of the unit without attachments is 210 kg.

An even more powerful model is the Zirka 151 walk-behind tractor, which is also professional. Its engine power is 15 hp, which allows you to easily process even very heavy and hard soil. The technical characteristics of the unit are as follows:

• • volume of one full fuel filling is 7 liters;
• • fuel consumption 2 l 900 ml per hour;
• • 6 speeds when moving forward;
• • 2 speeds when moving backwards;
• • cultivation depth 25 cm;
• • cultivation width 1 m;
• • machine weight 500 kg.

If necessary, buying spare parts for this Zirka walk-behind tractor is not difficult.

The Zirka 1090 D walk-behind tractor model is slightly less powerful. This machine has an engine with a maximum power of 11 hp. and a nominal 9 hp, which makes this Zirka walk-behind tractor suitable for all types of soil. This unit has the same speeds as the previous model. The depth of tillage with the Zirka 1090 walk-behind tractor is 19 cm, and the width is 78 cm.

Important Technical characteristics of the ANT 1000 mini loader and its modifications

All Zirka diesel walk-behind tractors are very reliable and durable.

Technical features

Most models of light and medium-sized Zirka walk-behind tractors are equipped with an active air cooling system, but water-cooled units are also produced. Special antifreeze or water can be used as a coolant for such systems; it is only necessary to control its level during operation. In the cold season, water must be drained after work.

The gearboxes on Zirka walk-behind tractors are manual, mostly of a combined type, designed for 6 speeds, two reverse gears, only light models use two-stage transmissions with reverse. The clutch system is dry, single-disc or multi-disc in an oil bath.

Fuel consumption in the most powerful Zirka model does not exceed 3 l/hour; fuel tanks for each model are selected with such a volume that there is no interruption for refueling for 3 hours or more. To transmit torque to the wheels, a belt drive is used on each wheel.

No. 3 – Huter MK-11000(M)

Price: 38,100 rubles

Another Huter, but this time it’s super powerful – 11 horses is no joke. The engine is made with the latest technology, no overheating and starting without oil. Driving such a handsome car is a pleasure - it’s easy and your hands don’t get tired. In the kit you can find all the necessary brackets, cutters and other nice bonuses.

The disadvantages may only relate to the build quality, but judging by the reviews of the owners - problems arise in the rarest cases, most of the batch did not cause any complaints from the happy owners of these walk-behind tractors.

If you have a large plot and you need a really powerful workhorse that is not afraid of any work, pay special attention to this option, the device is definitely worth the money. Huter MK-11000(M). Huter MK-11000(M)

Huter MK-11000(M)

What it is?

The Zirka walk-behind tractor, produced by a Chinese manufacturer, is a mechanized device that can be used both for processing small plots and areas up to 5 hectares. Such walk-behind tractors are especially suitable for small and medium-sized areas where there is no room for large equipment to turn around. The manufacturer, taking into account the financial capabilities and technical needs of customers, constantly expands its product line with new modifications that are designed for the middle class consumer. In addition, Zirka walk-behind tractors are characterized by low fuel consumption, excellent maneuverability and mobility. This increases demand for them, making the units popular all over the world.

The manufacturer equips these machines with motors of different power. Therefore, for summer cottages you can purchase economical options with a 4 liter gasoline engine. pp., but for large farms, professional walk-behind tractors are better suited. They have a diesel engine with a power of over 6 liters. With. It is worth noting that the motors of Zirka walk-behind tractors are considered the most powerful and reliable among other analogues. For example, the Zirka GN-151E unit model has a 15 hp diesel engine. With.

Heavy gasoline and diesel walk-behind tractors are additionally equipped with an electronic starter, which makes them easier to start. As for medium and light modifications, they start without any problems using a manual starter. Each Zirka unit model is designed for a specific amount of work. Most of them are capable of cultivating land plots up to 1.4 hectares wide, making depressions in the soil of 30 cm. The simplest modifications can easily cope with cultivating areas of 1.5 hectares, and their performance depends on the power of the motor and mounted or trailed equipment.

Almost all walk-behind tractors of this brand are equipped with an air cooling system; there are also modifications with water cooling. In such units, both water and special antifreeze are used as a coolant. In water-cooled devices, the liquid level must be constantly monitored; in winter, it is drained after work is completed. The gearboxes in the Zirka walk-behind tractor can be manual or combined; they are designed for two reverse gears and six speeds. The clutch system in the units, depending on the features of the model, can be multi-disc oil and dry single-disc.

The main advantage of walk-behind tractors is their minimal fuel consumption. As a rule, no more than three liters of gasoline or diesel fuel are consumed per hour of operation. A belt drive is installed on each wheel of the walk-behind tractor. It ensures the transmission of torque from the engine to the chassis. In addition, Zirka units are equipped with a take-off shaft, which makes them multifunctional, versatile and increases the productivity of attachments.

"Zirka" - good quality walk-behind tractor from China

Walk-behind tractors and cultivators are designed to help the average villager and owners of small cultivated plots ranging from several hundred to 2-5 hectares.
This technique is especially relevant in small or fractional areas, where the tractor has no room to turn around, manual control ensures mobility and maneuverability, and fuel consumption is significantly lower. Often, users complain about the quality, but, taking into account the skill of handicraftsmen, they compensate for the shortcomings with their own made parts and modifications. Manufacturers of walk-behind tractors under the Zirka brand present a wide range of small agricultural equipment, designed for buyers with various technical needs and financial capabilities.

Such equipment cannot be called cheap; Zirka walk-behind tractors are in the middle price segment and have a good price-quality ratio. Compared to the quality and prices of domestic ones (motorcycle wheels), it looks profitable, and given the established supply of spare parts from China, it is able to compete in the fight for consumers in our market.

Gasoline models

The main gasoline-powered products include three models: Zirka BD70G01, Zirka GT70G01 and Zirka GT90G03. Let's look at the technical characteristics of each of them.

BD70G01

A gasoline walk-behind tractor whose weight is 95 kg and power is 7 l/s. Main characteristics:

1. The cultivation width ranges from 45 to 86 centimeters.
2. Cultivation depth – 33 cm.
3. The amount of oil in the gearbox is 1.9 liters.
4. If there is a trailer, the loading weight is 250 kg.
5. The walk-behind tractor has two speeds.
6. Engine type – 1 cylinder, 4 stroke.
7. Air cooling.
8. Manual start type.

The fuel tank capacity is 3.6 liters.

This walk-behind tractor has its own specifics

GT70G01

This walk-behind tractor is heavier than the previous one (100 kg) and is capable of carrying more weight (350 kg). Designed for cultivating small and medium-sized plots of land. In addition, it differs in some technical features:

1. Cultivation width – 622/874/1136 centimeters.
2. Equipped with a four-stroke single-cylinder engine.
3. The cultivation depth is 15-30 cm.
4. 2 gears.
5. Air-cooled engine with a power of 7 l/s.
6. Fuel tank volume is 3.6 liters.
7. Manual start.

GT70G01 has a direct drive with worm gear and bevel gear.

GT90G03

This product is characterized by increased engine power (9 horsepower), as well as an expanded fuel tank (6 l). Advantages also include the presence of reverse gear for increased maneuverability.

Other characteristics:

1. Weight – 130 kg.
2. Cultivation width – 874/1136/1406 cm.
3. Depth – 15-30 cm.
4. Gearbox oil – 1.7 l.
5. Cargo weight with trailer – 350 kg.
6. The engine has 1 cylinder, 4 strokes and a horizontal crankshaft.
7. Cooling type – air.

The launch occurs manually.

This walk-behind tractor is air cooled

Model range overview

The power of Zirka walk-behind tractors ranges from 4 to 10 horsepower. The most important advantage of this technology is, of course, its engine. The machine body is made of high strength materials, corrosion-resistant, high quality and wear-resistant. The devices have a recognizable design. Engine type: diesel or gasoline, cooling system - water or air, depending on the modification. Engine stroke: 4, number of cylinders: 1.

Gasoline walk-behind tractors

Representatives of the gasoline class of Zirka walk-behind tractors:

• GT90G03, 9 hp;
• BD70G01, 7 HP;
• GT70G01, 7 hp;
• LX2060G, 6.5 hp;

• LX2062G, 6.5 hp;
• LX3060G, 6.5 HP;
• MF360, 6.5 hp;
• LX2064G, 6.5 HP

Fuel type: gasoline AI95, AI92. Oil for air-cooled gasoline engines.

Complete set of Zirka petrol walk-behind tractors

Diesel walk-behind tractors

Representatives of the diesel class of Zirka walk-behind tractors:

• GT76DE, 7.6 hp;
• GT76D, 7.6 hp;
• GT90D04E, 9 hp;
• WC10D, 10 HP;
• WC10DE, 10 hp;
• WC80D, 8 hp;

• WC80DE, 8 hp;
• GT76D02, 7.5 hp;
• GT76D02E, 7.5 hp;
• LX2040D, 4 HP;
• LX2060D, 6 HP;
• LX2062D, 6 HP;
• LX2063D, 6 HP;
• LX2092D, 9 hp;

• LX2094D, 9 hp;
• LX3040D, 4 HP;
• LX3060D, 6 HP;
• LX1091D, 10 HP

Type of fuel for refueling: diesel, any manufacturer. Oil for the appropriate type of engine, taking into account the type of cooling.

Getting to know the brand's most popular models

Among the variety of options on the market, some units have received the greatest attention. This was facilitated by practicality, affordability, performance, excellent performance and endurance. We are talking about Zirka 105, Zirka BD70G01 and Zirka GT90G03 walk-behind tractors.

Motoblock Zirka 105

Thanks to its average parameters, small dimensions and reasonable price, this device is the most optimal choice, ideal for working both in large areas and in small garden plots. This compact device packs incredible power. Specifications:

• Diesel engine power – 6 liters. With.;
• The device starts thanks to a manual starter;
• The fuel tank capacity reaches 3.5 liters;
• Weight – 115 kg;
• Engine type – single-cylinder SH178F;
• Cooled by air cooling (forced);
• The lubrication system operates under pressure.

The model can cultivate soil in one go, the width of which does not exceed 100 cm (depth - 16 cm).

Walk-behind tractor Zirka BD70G01

This option is a worthy representative of the middle class, because it is most often used on areas of up to 0.6 hectares and can transport cargo weighing up to 250 kg. The set includes a set of 8 rototillers, which are easily installed on the drive shaft.

Technical features:

• Oil volume in the gearbox – 1.9 l;
• Fuel tank – 3.6 l;
• Fuel - gasoline;
• Cooling type – air;
• Weight – 95 kg;
• Engine power – 7 l. With;
• The maximum number of engine revolutions per minute is 3600.

This model is complemented by a special three-groove pulley, which allows you to connect a completely variety of attachments or operate the walk-behind tractor as a drive unit.

Motoblock Zirka GT90G03

The model is distinguished by the presence of a reliable gasoline engine with a capacity of 9 liters. With. Special pneumatic wheels are mounted on the drive shaft, guaranteeing maneuverability in the most difficult areas.

Specifications:

• Weight – 130 kg;
• Oil volume in the gearbox – 1.7 l;
• Engine displacement – ​​270 cm3;
• The maximum weight of cargo for transportation is 350 kg;
• Transmission – worm gearbox with bevel gear;
• Cooling is air.

It is worth noting that with the help of Zirka walk-behind tractors the company is only just exploring the domestic market and soon we should expect pleasant modifications that will positively affect the performance of the devices.

Walk-behind tractor zirka iz 105 e

The professional diesel walk-behind tractor Zirka IZ 105 is designed to perform a range of agricultural work. The Zirka 105 walk-behind tractor will be an excellent assistant in private households and on personal plots. The walk-behind tractor is equipped with a reliable diesel engine with a power of 6.0 hp.

This model is capable of cultivating soil 100 cm wide and up to 16 cm deep in one visit. Thanks to the adjustable steering column and thoughtful design, the walk-behind tractor is easy to operate and has good maneuverability.

Video: harvesting potatoes with a Zirka 105 walk-behind tractor